Accidents

  • | | | | | | |

    FERC Stops Rover Drilling Near River After 200K Gal Mud Disappears

    The Ohio EPA continues its yapping insistence that the Federal Energy Regulatory Commission (FERC) *permanently* shut down underground horizontal directional drilling (HDD) work being done by Rover Pipeline near the Tuscarawas River over concerns that nontoxic (totally safe) drilling mud keeps disappearing down the borehole. FERC listened, sort of. In an order dated yesterday, FERC told Rover to *temporarily* stop HDD work at Tuscarawas until Rover can outline a plan for moving forward that FERC has confidence will address concerns over the disappearing drilling mud. When mud used for drilling holes comes out on the surface any place other than the hole from which it went down, it’s called an “inadvertent return.” We call it a leak. However, if that same mud never comes back to the surface, as sometimes happens, it’s fine. Except when it’s a LOT of mud, as is the case in drilling near Tuscarawas where a cumulative 200,000 gallons of it have disappeared down hole, not (so far) coming back out. Sooner or later it seems likely that at least some of that mud will come back to the surface–somewhere. That’s the concern that no doubt prompted FERC to send Rover a letter yesterday telling them to (for now) stop HDD work at Tuscarawas…
    Read More “FERC Stops Rover Drilling Near River After 200K Gal Mud Disappears”

  • | | | | | | |

    Ohio EPA Continues Campaign to Stop Rover Pipe, Hounds FERC Again

    The Ohio Environmental Protection Agency (OEPA) continues to hound the Federal Energy Regulatory Commission (FERC) about a potential spill of drilling mud by Rover Pipeline near the Tuscarawas River. Last week we told you that OEPA, which has ZERO regulatory oversight of the Rover Pipeline project, had been told (by informants) that when Rover restarted underground horizontal directional drilling (HDD) work at the Tuscarawas site, some 146,000 gallons of drilling mud went down the hole but never came back out (see OEPA Continues to Hunt Rover Pipe, Claims 2nd Spill Near River). In April 2017 Rover experienced an inadvertent return (i.e. spill) of some 2 million gallons of drilling mud at the same location (see Rover Pipeline Accident Spills ~2M Gal. Drilling Mud in OH Swamp). Last year’s accident shut down all HDD work for months. It wasn’t until December that FERC allowed Rover to restart HDD work at the Tuscarawas site. After OEPA went blabbing to FERC last week, Rover pushed back by saying there has been no spill or inadvertent return (see Rover Refutes Ohio EPA Claim of 146K Gal. Spill @ Tuscarawas River). We theorize that some (maybe even all 146,000 gallons) of the drilling mud did go down the hole and stayed down the hole. So far it hasn’t come back out, which is not a problem in anyone’s book. OEPA was back at FERC on Friday like an ankle-biting Chihuahua, asking FERC to shut down Rover HDD work because of this unsubstantiated rumor of drilling mud gone missing. Enough is enough! When will FERC slap OEPA around and tell them to back off?…
    Read More “Ohio EPA Continues Campaign to Stop Rover Pipe, Hounds FERC Again”

  • | | | | | | |

    Rover Refutes Ohio EPA Claim of 146K Gal. Spill @ Tuscarawas River

    Yesterday we brought you the news that the Ohio Dept. of Environmental Protection (OEPA) had made claims, in a letter to the Federal Energy Regulatory Commission (FERC), that Rover Pipeline’s restart of underground horizontal directional drilling (HDD) near the Tuscarawas River had resulted in a second large spill of drilling mud–146,000 gallons (see OEPA Continues to Hunt Rover Pipe, Claims 2nd Spill Near River). OEPA claims to have spies that told them that while drilling 146,000 gallons of drilling mud had disappeared “down hole.” That typically means the mud will reappear somewhere on the surface. OEPA does not regulate the Rover project–it is a FERC/federally regulated project. And that frosts OEPA’s director, tattletale Craig Butler. Except this time it appears OEPA was mistaken, or perhaps acting on bad information. According to a statement by Energy Transfer, builder of Rover, there has been no “release” or “spill” of drilling mud a second time at the Tuscarawas River site…
    Read More “Rover Refutes Ohio EPA Claim of 146K Gal. Spill @ Tuscarawas River”

  • | | | | | | | |

    OEPA Continues to Hunt Rover Pipe, Claims 2nd Spill Near River

    Ohio EPA (OEPA) director Craig Butler, aka Captain Ahab, continues his mission to harpoon that rascally great white whale known as the Rover Pipeline. Somehow Captain Ahab, er, a, Mr. Butler has “learned” that underground horizontal directional drilling (HDD) Rover was recently allowed (by the Federal Energy Regulatory Commission) to resume near the Tuscarawas River (over the objections of OEPA) has “lost” 146,000 gallons of drilling mud “down hole.” This is at the same location where Rover previously lost 2 million gallons of drilling mud down hole, some of which turned up back on the surface, at a swamp (aka “wetland”) located next to the Tuscarawas (see Rover Pipeline Accident Spills ~2M Gal. Drilling Mud in OH Swamp). That 2 million gallon “spill” in April of last year triggered a shutdown of all HDD work in Ohio. It was only in December that Rover was allowed, by FERC, to resume more HDD work at the Tuscarawas site (see FERC Gives Rover OK to Resume All HDD Work, Incl. Tuscarawas River). Butler’s spies have reported to him that more drilling mud, some 146,000 gallons, has disappeared into the earth during HDD drilling at the Tuscarawas site. Some perspective on this alleged news: First, how did Butler even know of a “problem”? OEPA doesn’t regulate the Rover project! Second, since Rover doesn’t answer to OEPA (which frosts Butler), Butler runs like a tattling child to FERC with every perceived violation he can trump up–even though he doesn’t have all the facts. Third, even though drilling mud may disappear down hole, that doesn’t mean the mud comes back to the surface. Sometimes it stays down there–forever. Fourth, even if the mud does come back to the surface, drilling mud is nontoxic–the same stuff used in kitty litter, cosmetics and toothpaste. The only thing an overabundance of spilled mud can do is smother a few fish. This latest ploy by Butler to tattle on Rover to FERC is his attempt to try and manipulate FERC into shutting down Rover’s HDD work once again…
    Read More “OEPA Continues to Hunt Rover Pipe, Claims 2nd Spill Near River”

  • | | | | | | |

    Belmont OH Family Sues Summit Midstream for Mud Spill Near Home

    Summit Midstream Partners was drilling underneath a road and a creek in Belmont County, OH on Oct. 19 to install a pipeline when they experienced an “inadvertent return” (i.e. leak) of drilling mud into the creek. If you’ve read MDN for any length of time, you will have read about other such instances by other companies. Because we constantly have new readers, we post the following explanation, which will sound like a broken record for long-time readers: Drilling mud is bentonite, a form of non-toxic clay also used to make kitty litter, cosmetics and toothpaste–among many, many other consumer products. The only threat posed by a spill of bentonite is that enough of it spills to clog the gills of fish or smother little critters like salamanders. That’s it. Think about taking half a dozen bags of kitty litter to a creek nearby and dumping them all in. It’s nothing. No pollution. We’d certainly rather not have any such accidents–but the reality is, they sometimes happen. That’s why non-toxic bentonite is used. The Ohio EPA stepped in and cited/fined Summit for the spill. Fair enough. But that’s not what this story is about. This story is about a family that lives near the spill. They hated Summit’s “loud” drilling before the spill, and now are using Summit’s spill and cleanup work (some of it happening in their front yard) as an excuse to sue Summit, hoping to score big bucks. Good luck with that…
    Read More “Belmont OH Family Sues Summit Midstream for Mud Spill Near Home”

  • | | | | | |

    DEP: No Contamination from 63K Gal. Inflection Energy Brine Spill

    Around 63,000 gallons of treated brine (naturally occurring, very “salty” water that comes out of a well long after it’s drilled) spilled in an accident at an Inflection Energy well pad in Eldred Township, Lycoming County, PA in mid-November (see 63K Gal. Brine Spill at Inflection Well Pad in Lycoming County). Inflection blamed a contractor and operator error for the spill, which happened after an already-full tank was overfilled. Some of the brine reached a nearby unnamed creek that flows into the Loyalsock Creek. In a followup to that story, tests done since the spill on eight private water wells close to the Inflection well pad show no contamination. Zero. We’re still waiting on test results for four other wells. The tanks holding the brine (that overflowed) have been removed from the well pad. No contamination was found in the Loyalsock or in the Susquehanna River, which the Loyalsock empties into. It’s never a good thing to have a spill like this, but the good news is that there is no lasting environmental impact from it. Here’s an update on the November spill and its cleanup…
    Read More “DEP: No Contamination from 63K Gal. Inflection Energy Brine Spill”

  • | | | | |

    Small Marcellus Well Pad Fire in Somerset PA Leads to Evacuations

    This is the second day in a row we’ve had to bring you news of a fire at a Marcellus Shale well site. Yesterday we told you about a fire at an EQT well pad in Marshall County, WV (see Fire at EQT Well Pad in Marshall County, WV). That fire started in gas processing equipment near the well. Like yesterday’s WV news, today’s news of a fire in Pennsylvania also concerns equipment being used at the well pad–NOT a fire in the actual well itself nor anything to do with drilling or fracking. The well pad in question is the first location where Marcellus wells were drilled in Somerset County–a decade ago. Yesterday a fire ignited around 9 am at the Menhorn well pad, owned by Xtreme Energy. The fire “was in a flange next to the cooling tower” at the well pad. The fire was out within an hour. Nobody was injured, although firefighters did evacuate four nearby homes (eight people) just to be safe. The all-clear was given by 10:30 am. The state Dept. of Environmental Protection (DEP) is on the site and a preliminary report concludes “the equipment associated with the well failed and caught fire, but the wellhead was not on fire.” Here’s the details as we have them…
    Read More “Small Marcellus Well Pad Fire in Somerset PA Leads to Evacuations”

  • | | | | | |

    Fire at EQT Well Pad in Marshall County, WV

    Yesterday, gas processing equipment at a Trans Energy well pad (now owned by EQT) in Marshall County, WV caught fire. The important things to know: (1) The fire was quickly extinguished, (2) nobody was injured, (3) this was not a well fire and was not related to drilling or fracking. There is a single operating Marcellus well at that location–drilled back in 2011. The well has been producing natural gas and other hydrocarbons since that time. As is common, some of the hydrocarbons (like condensate) are separated right at the well location, by equipment located near the pad. The fire began in that processing equipment. No residents were evacuated and the fire was out within a few hours. However, workers at the nearby Williams Fort Beeler natural gas processing plant were evacuated for a brief time, out of “an abundance of caution”…
    Read More “Fire at EQT Well Pad in Marshall County, WV”

  • | | | | | | |

    PA Supreme Court Hears Arguments in EQT Wastewater Leak Case

    Buckle up while we explain the background for this story. In October 2014, the DEP fined EQT a whopping $4.53 million for a leaky wastewater impoundment in Tioga County, PA (see PA DEP Levies Biggest Fine Ever, $4.5M Against EQT). While EQT did not say there wasn’t a problem with leaks at the site, they did say the way the DEP calculated the fine is unreasonable and arbitrary. In fact, EQT says the DEP levied the fine and took EQT to court because a few weeks prior EQT had sued the DEP over a different matter–that is, sour grapes. EQT appealed the fine and the case all the way to the PA Supreme Court. In December 2015, the high court handed EQT a “procedural victory” by saying EQT has a point about the manner in which the DEP is calculating the fine (see PA Supreme Court Gives EQT “Procedural Victory” in $4.5M Fine Case). The Supreme Court sent the case back to a lower court, PA Commonwealth Court, for follow up work, and in January 2017, a three-judge panel ruled that the method the DEP currently uses to assess fines–by how many days pollution lingers, instead of by how many days the initial release of pollution lasted–is not legal nor common sense (see EQT Wins Court Case Against PA DEP re $4.5M Wastewater Leak Fine). The judges said such a method in fining, “would result in potentially limitless continuing violations.” Under the old way of calculating fines, the DEP was considering upping the fine on EQT to an insane $157 million. Calculating it under the new way will mean a fine of around $120,000. Not long after that ruling, the Environmental Hearing Board, a special “court” set up to hear appeals of DEP decisions, decided to reduce the original $4.5 million fine down to $1.1 million (see PA Hearing Board Reduces EQT Fine from $4.5M to $1.1M). We thought that would be the end of it. But no! Both the DEP and EQT appealed the matter back up to the PA Supreme Court and yesterday the Supremes heard the case once again…
    Read More “PA Supreme Court Hears Arguments in EQT Wastewater Leak Case”

  • | | | | | |

    63K Gal. Brine Spill at Inflection Well Pad in Lycoming County

    Approximately 63,000 gallons of treated brine (naturally occurring, very “salty” water that comes out of a well long after it’s drilled) spilled in an accident at an Inflection Energy well pad in Eldred Township, Lycoming County, PA, on Monday. Inflection blames a contractor and operator error for the spill, which happened after an already-full tank was overfilled. Some of the brine (no word on how much) reached a nearby unnamed creek that flows into the Loyalsock Creek. However, testing done on the Loyalsock shows no presence of contamination. The Loyalsock flows into the Susquehanna River, and the Susquehanna is used as a public drinking water source–hence the concern. There are no warnings to public drinking water operations along the Susquehanna because there is no problem to report. Now comes an investigation, and no doubt fines, for the accident. Here’s what we’re able to find out about the episode–an occurrence so rare it’s newsworthy when it happens…
    Read More “63K Gal. Brine Spill at Inflection Well Pad in Lycoming County”

  • | | | | | |

    Explosion at Columbia Pipeline Meter Station in NE OH Kills Worker

    Stark County, OH

    In a tragic accident, one worker was killed and another injured while working at a Columbia Gas Transmission pipeline metering station in Stark County, OH on Monday. Media reports say Wesley J. Johnson, 60, of Wooster, OH was standing near the pipe when the end cap came off the pipe and the pressure of the gas in the line exploded outward (not igniting), throwing Johnson backward into a fence. He died instantly from massive trauma to his chest. The pipe valve has been sent to a crime lab to determine what happened. Residents living in the area around the metering station were evacuated for 45 minutes, until the all-clear was given for them to return. Nearby residents reported hearing an explosion and said the sound of the gas coming out of the pipeline was loud–like a jet engine. It’s always a sad day when we have to report of a fatality in the industry…
    Read More “Explosion at Columbia Pipeline Meter Station in NE OH Kills Worker”

  • | | | | | | |

    Michigan DEQ Claims Rover Discharged Polluted Water into Wetland

    Rover Pipeline has been served a violation from the Michigan Dept. of Environmental Quality claiming the company discharged polluted water from its drilling operations into a wetland. Which may sound familiar, because Rover was cited for fouling a wetland in Ohio with 2 million gallons of drilling mud back in April (see Rover Pipeline Accident Spills ~2M Gal. Drilling Mud in OH Swamp). However, the Michigan story is completely different. Water coming from the pipeline project in Michigan (Washtenaw County) appears to contain gasoline in it. The water has a “sheen” and smells of petroleum. The DEQ theorizes that Rover’s work in the area has disturbed existing underground pollution from a now-closed gas station. Water that previously seeped into ground and was polluted by the old gas station is now (according to the theory) making its way into an area wetland. The pollution already existed–Rover didn’t cause the pollution. But the DEQ says Rover work caused the pollution to change locations, so Rover is to blame…
    Read More “Michigan DEQ Claims Rover Discharged Polluted Water into Wetland”

  • | | | | | |

    ME2 Pipe Blasting in Lebanon County Uncovers Old Pollution

    Blasting and drilling work in Lebanon County, PA related to building the Mariner East 2 Pipeline may have caused old deposits of MTBE (a gasoline additive) that had been stored at an old Sunoco facility to dislodge and migrate–into a nearby farmer’s water well. A subcontractor doing blasting work on Sept. 11 experienced “complications” during a detonation. Pieces of rock and debris hit a nearby house and swimming pool. Not a good thing. That blasting may also have led to the migration of MTBE to a nearby farm where MTBE had not previously been detected. Also not a good thing. Sunoco used to operate the Quentin terminal from 1940 to 1993 that served as a petroleum storage facility for the original Mariner East Pipeline–that flowed petroleum. That pipeline has since been repurposed and now flows natural gas liquids. Leaks from the old storage facility were known to have contaminated the ground in the area. It appears the blasting may have disturbed some of the pollution sitting under ground…
    Read More “ME2 Pipe Blasting in Lebanon County Uncovers Old Pollution”

  • | | | | | |

    PA AG Criminal Lawsuit Against XTO Energy Dismissed After 4 Yrs

    Four years after then-Pennsylvania Attorney General Kathleen Kane decided to turn an accident into a criminal prosecution against XTO Energy, the final chapter has been written. Anti-drilling Kane attempted to criminalize the accidental spill of a small amount of recycled wastewater by XTO that happened years before she took office (see PA AG Abuses Her Authority, Files Criminal Charges Against XTO). There was an accidental spill of ~50,000 gallons of frack wastewater at an XTO drill site in 2010 in Lycoming County, PA. XTO remediated the site, digging up affected soil, and paid out a $100,000 settlement in 2013. By the time Kane took office, the matter had been over and done for over two years. But Kane wanted/needed a quick way to make a splash with her hardcore left fringe supporters (payback time for money and volunteers), so she re-opened the case and fantastically filed criminal charges saying XTO showed a pattern of brazen disregard for safety, blah blah blah. In 2013, XTO filed to dismiss the Kane lawsuit (see XTO Energy Files to Have AG Kane’s Lawsuit Dismissed). The federal EPA also got into the act and last year XTO settled a violation of the Clean Streams Law and Solid Waste Management Act. Pricetag? Another $300,000. Now that the company has paid out the nose ($400,000 total), U.S. Middle District Judge Matthew Brann yesterday approved a motion filed by the U.S. attorney’s office to end the case. Finally. After four years…
    Read More “PA AG Criminal Lawsuit Against XTO Energy Dismissed After 4 Yrs”

  • | | | | | | | |

    Big Green Group Makes Big Deal Out of Tiny ME2 Mud Spill

    Will anti-fossil fuel Big Green groups succeed in turning a molehill into a mountain? That’s what they are attempting to do with the latest tiny spill (50 gallons) of drilling mud by Sunoco Logistics Partners in underground drilling work for the Mariner East 2 pipeline project in Dauphin County, PA. Over the past several months, Sunoco has experienced some “inadvertent returns” (i.e. leaks) of drilling mud at various locations. One of those was in Chester County, where a serious leak temporarily fouled a water aquifer and clouded drinking water for 15 local households (see Sunoco Stops ME2 Drilling in Chester County Following Water Issue). Sunoco took extraordinary steps to make it right, going so far as to pay to run municipal water to affected homeowners. Earlier this month Sunoco struck a deal with several Big Green groups to provide stricter regulation for ME2’s underground drilling (see Sunoco Strikes Deal with Devil, “Settles” with Anti Groups re ME2). Part of the deal says if Sunoco experiences two leaks of drilling mud at the same location, they must shut down drilling in that location and wait for the state Dept. of Environmental Protection to further review drilling plans before they can restart. On August 24th there was a 50-gallon drilling mud spill into the Susquehanna River in Dauphin County related to ME2. (A quick reminder: drilling mud, or “bentonite,” is non-toxic–the same stuff found in toothpaste and kitty litter). Thing is, there was another spill of 495 gallons at the same location a week earlier. Antis say Sunoco must now shut down drilling in that spot until further notice. Sunoco is saying that particular location was not part of the signed agreement…
    Read More “Big Green Group Makes Big Deal Out of Tiny ME2 Mud Spill”

  • | | | | | | |

    Tetco Pipe Drilling in Athens, OH Hits Gas Pocket, Catches Fire

    Click for larger version of map

    As part of drilling underground (directional horizontal drilling, or HDD), Enbridge hit a pocket of natural gas in Athens County, OH about 400 below the surface. The gas leaked out and caught fire last Wednesday, partially burning the drilling rig. Fortunately the rig operators have the presence of mind to evacuate quickly and no one was hurt. The fire closed a section of Route 681 southeast of Albany, OH until Friday afternoon. According to press reports, the work being done is for the Texas Eastern Transmission pipeline (Tetco). This next bit is our own conjecture (we are not 100% sure), but we think we know which Tetco-related project Enbridge was working on. A year ago, in August 2016, the Federal Energy Regulatory Commission (FERC) approved three Spectra Energy pipeline projects all part of the same package to flow more Marcellus/Utica gas to the South (see FERC Approves 3 Spectra Energy Pipe Projects in Marcellus/Utica). The three projects, which together will add an additional 662 million cubic feet (MMcf/d) of capacity along Tetco, are Access South, Adair Southwest and Lebanon Express. We believe the work being done was for this trio of projects. Given the location of the fire (Athens County), it was likely the Adair Southwest project (see the project map). The Enbridge website lists Range Resources as the shipper that reserved capacity along the Adair Southwest portion of the upgraded Tetco (200 MMcf/d of capacity). Below is the news would could find regarding the fire…
    Read More “Tetco Pipe Drilling in Athens, OH Hits Gas Pocket, Catches Fire”